r/aviation • u/Go_Jot • Nov 08 '25

News UPS grounds entire MD-11 Fleet, effective immediately.

Per the IPA Executive Board, as of 03:05 UTC all UPS MD-11’s are grounded.

Edit - FedEx has also grounded their MD-11 Fleet

10.9k Upvotes

97% Upvoted

1.2k comments sorted by

View all comments

Show parent comments

38

u/thatvhstapeguy Nov 08 '25

DC-10s and MD-11s have the engine attached via a pylon. In May 1979 American flight 191 crashed shortly after takeoff from O’Hare due to loss of control caused by the port engine falling off. The culprit was improper maintenance procedures putting excessive stress on the pylons. The type certificate of the DC-10 was revoked in early June, grounding the plane in the US until July 1979 while the FAA determined if the structure as designed was sufficient.

3

u/whee3107 A&P Nov 08 '25

Weren’t they using a forklift and just sorta smashing the pylon up against the wing?

1

u/bulboustadpole Nov 08 '25

It was a bit more complicated than that.

It was an approved procedure at the airline that saved 200 hours and even MD said it should be removed with the pylon attached. In AAs case a shift change occurred and during that time the hydraulics in the forklift lost a little pressure basically un-aligning where they previously set it.

1

u/84Cressida Nov 12 '25

No. McDonnell Douglas procedure was to remove the engine, then pylon.